Accident Boeing 747SR-46 JA8119, Monday 12 August 1985
ASN logo
 

Date:Monday 12 August 1985
Time:18:56
Type:Silhouette image of generic B74R model; specific model in this crash may look slightly different    
Boeing 747SR-46
Owner/operator:Japan Air Lines - JAL
Registration: JA8119
MSN: 20783/230
Year of manufacture:1974
Total airframe hrs:25030 hours
Cycles:18835 flights
Engine model:Pratt & Whitney JT9D-7A
Fatalities:Fatalities: 520 / Occupants: 524
Other fatalities:0
Aircraft damage: Destroyed, written off
Category:Accident
Location:26 km SW of Ueno Village, Tano district, Gunma Prefecture -   Japan
Phase: En route
Nature:Passenger - Scheduled
Departure airport:Tokyo-Haneda Airport (HND/RJTT)
Destination airport:Osaka-Itami Airport (ITM/RJOO)
Investigating agency: AAIC
Confidence Rating: Accident investigation report completed and information captured
Narrative:
JA8119 was a Japan Air Lines Boeing 747SR, a short range variant of the Boeing 747 Series 100. The was aircraft specifically configured for domestic flights with a high density seating arrangement.
On June 2, 1978 the aircraft operated on a flight to Osaka (ITM). It floated after touchdown and on the second touchdown the tail struck the runway. The aircraft sustained substantial damage to the rear underside of the fuselage. The rear pressure bulkhead was cracked as well. The aircraft was repaired by Boeing. Engineers replaced the lower part of the rear fuselage and a portion of the lower half of the bulkhead.
Seven years later, on August 12, 1985, JA8119 had completed four domestic flights when it landed at Tokyo-Haneda (HND) at 17:17. The next flight was to be flight 123 to Osaka (ITM). The aircraft took off from Tokyo-Haneda at 18:12. Twelve minutes later, while climbing through 23900 feet at a speed of 300 knots, an unusual vibration occurred. An impact force raised the nose of the aircraft and control problems were experienced. A decompression had occurred and the crew got indications of problems with the R5 door. In fact, the rear pressure bulkhead had ruptured, causing serious damage to the rear of the plane. A portion of its vertical fin, measuring 5 m together with the section of the tailcone containing the auxiliary power unit (APU) were ripped off the plane. Due to the damage, the hydraulic pressure dropped and ailerons, elevators and yaw damper became inoperative. Controlling the plane was very difficult as the airplane experienced dutch rolls and phugoid oscillations (unusual movement in which altitude and speed change significantly in a 20-100 seconds cycle without change of angle of attack).
The aircraft started to descend to 6600 feet while the crew tried to control the aircraft by using engine thrust. Upon reaching 6600 feet the airspeed had dropped to 108 knots. The aircraft then climbed with a 39 degree pitch-up to a maximum of approx. 13400 feet and started to descend again. At 18:56 JAL123 finally brushed against a tree covered ridge, continued and struck the Osutaka Ridge, bursting into flames.

CAUSE: "It is estimated that this accident was caused by deterioration of flying quality and loss of primary flight control functions due to rupture of the aft pressure bulkhead of the aircraft, and the subsequent ruptures of a part of the fuselage tail, vertical fin and hydraulical flight control systems.
The reason why the aft pressure bulkhead was ruptured in flight is estimated to be that the strength of the said bulkhead was reduced due to fatigue cracks propagating at the spliced portion of the bulkhead's webs to the extent that it became unable to endure the cabin pressure in flight at that time.
The initiation and propagation of the fatigue cracks are attributable to the improper repairs of the said bulkhead conducted in 1978, and it is estimated that the fatigue cracks having not be found in the later maintenance inspection is contributive to their propagation leading to the rupture of the said bulkhead."

Accident investigation:
cover
  
Investigating agency: AAIC
Report number: Final report
Status: Investigation completed
Duration: 1 year and 10 months
Download report: Final report

Sources:

Applying Lessons Learned From Accidents : Accident/Incident Summary Japan Airlines Flight 123, Boeing 747, Gunma Prefecture Japan
Flight International 14 September 1985 (4-7)
Job, Macarthur and Steve Swift. JAL 123: 520 Lost - It's 20 years since the world's worst single aircraft airliner accident. In: Flight Safety Australia. - Vol. 9, no. 4 (July, August 2005) page 28-33. [http://www.casa.gov.au/fsa/2005/aug/28-33.pdf]

History of this aircraft

Other occurrences involving this aircraft

2 June 1978 JA8119 Japan Air Lines - JAL 0 Osaka-Itami Airport (ITM) sub

Statistics

  • worst accident in 1985
  • worst accident of this aircraft type
  • worst accident of this aircraft type at the time

Location

Images:


photo (c) Werner Fischdick; Osaka-Itami Airport (ITM); 17 August 1984


photo (c) Harcmac60; Osaka-Itami Airport (ITM); 1984; (CC:by-sa)


photo (c) Kjell Nilsson; Tokyo-Haneda Airport (HND/RJTT); 16 April 1984; (CC:by-sa)

Revision history:

Date/timeContributorUpdates

The Aviation Safety Network is an exclusive service provided by:
Quick Links:

CONNECT WITH US: FSF on social media FSF Facebook FSF Twitter FSF Youtube FSF LinkedIn FSF Instagram

©2024 Flight Safety Foundation

1920 Ballenger Av, 4th Fl.
Alexandria, Virginia 22314
www.FlightSafety.org